40,000km service coupon, emission control versions

Operation 0010K40 · Programmed maintenance, emission control versions up to 90,000km

Position the vehicle on a lift.

Check the tyre tread is not irregularly worn.

Some types of tyre are fitted with wear gauges; these tyres should be replaced as soon as these gauges are visible on the tread.

The tyre pressures must be checked when they are cold.

Check that the lighting system is operating correctly: headlamps, turn signals, hazard lights, luggage compartment light, passenger compartment light, oddment compartment light and instrument panel warning lights.

Check the windscreen wiper system is operating correctly and adjust the sprays if necessary.

Check the front and rear wiper blades are correctly positioned and not worn.

Remove the front wheels

Op. 4450B12 FRONT WHEELS (TWO) - R.R.

, then visually inspect the condition of the front disc brake pads and ensure they are not worn.

Carry out a visual check of:

body exterior

underbody protection

rigid and flexible pipe sections (exhaust, fuel system, brakes)

rubber components (gaiters, sleeves, bushes etc.)

Check that the bonnet and boot are clean and that the linkage is clean and lubricated.

1.2 8v · Heater

Visually inspect the condition of the alternator drive belt.

Visually inspect the condition of the power assisted steering pump drive belt.

1.2 8v · Climate control system

Visually inspect the condition of the alternator drive belt.

Visually inspect the condition of the compressor drive belt.

Visually inspect the condition of the power assisted steering pump drive belt.

1.9 JTD 8V, 1.9 DIESEL

Proceed with check the tappet clearance and adjust, if necessary

Op. 1036H10 VALVE TAPPETS - CHECK AND ADJUST CLEARANCE

1.2 8v

Proceed with check the tappet clearance and adjust, if necessary

Op. 1036H10 VALVE TAPPETS - CHECK AND ADJUST CLEARANCE

All versions

Check and, if necessary, adjust handbrake lever

Op. 3380A04 HANDBRAKE - ADJUST TRAVEL

1.3 JTD 16V, 1.9 JTD 8V, 1.9 DIESEL

Check the exhaust gas emissions/fumes

Op. 1080a20 SMOKINESS AT EXHAUST - CHECK WITH OPACIMETER

1.9 DIESEL

Replace the fuel filter

Op. 1044B10 FUEL FILTER ASSEMBLY - R + R OR REPLACE

1.9 JTD 8V

Replace the fuel filter

Op. 1044B20 FUEL FILTER FILTERING ELEMENT - REPLACE

1.2 8v, 1.4 8v, 1.6 16v, 1.9 JTD 8V, 1.9 DIESEL

Change the air cleaner cartridge

Op. 1048A14 AIR CLEANER FILTERING ELEMENT - REPLACE.

All versions

Check and, if necessary, top up the engine coolant level.

Op. 0010T21 COOLANT - CHECK DENSITY AND TOP UP IF NECESSARY

Check and, if necessary, top up the brake fluid level.

Op. 0010T64 BRAKE AND/OR CLUTCH FLUID CHECK LEVEL AND TOP UP AS NECESSARY

Check and, if necessary, top up the windscreen washer fluid level

Op. 5050A14 RESERVOIR PLUG (IN ENGINE COMPARTMENT) OR WINDSCREEN WASHER FLUID LEVEL SENSOR - CHECK AND TOP UP IF NECESSARY

Check and, if necessary, top up the battery fluid level.

Check and, if necessary, top up the power assisted steering fluid level

Op. 0010T71 POWER STEERING FLUID CHECK LEVEL AND TOP UP IF NECESSARY

1.2 8v, 1.4 8v, 1.6 16v

Replace the spark plugs.

Op. 5510D10 SPARK PLUGS - R+R

All versions

Connect the EXAMINER or other diagnostic equipment to the diagnostic socket (select the control unit in question), then check the plausibility of all the parameters and, if necessary, carry out the active diagnosis.

Change the engine oil and filter

Op. 0010T12 ENGINE OIL AND FILTER - REPLACE

Replace the pollen filter

Op. 5010B09 PURIFYING (POLLEN) FILTER FILTER ELEMENT - REPLACE

The pollen filter should be replaced every 24 months.

Remove the vehicle from the lift.